•  
  •  
 

Coal Geology & Exploration

Abstract

Background Thermal stimulation of coal seams using high-temperature steam is recognized as a highly promising technology used to increase gas production. Steam permeability serves as a critical parameter for characterizing the injection capacity of thermal fluids. However, the seepage patterns and evolutionary mechanism of steam in coals remain unclear, and exploring these issues holds critical scientific significance for gas production enhancement via heat injection. Methods Through experiments on the seepage and thermal strains of coals during the injection of high-temperature steam performed using the steady-state method, this study investigated the dynamic time variation patterns of the steam permeability and thermal strains of coals. Based on the theories of the Kelvin equation for capillary condensation, slug flow, and thermal stress, this study analyzed the evolutionary mechanisms behind the condensation-induced phase transition and pulsating seepage of steam in coals and behind the thermal strain of coals. Results The experimental results indicate that during the injection of high-temperature steam into coals, the liquid-measured permeability of steam showed an intermittent pulsating pattern with an increase in the heat injection time. A higher steam temperature corresponded to a decreased pulsating peak, a shortened pulsating cycle, and more intense pulsation. During heat injection, the radial and volumetric strains of coals exhibited two to three stages of expansion. The axial strain was manifested as compressive strain under lower steam temperatures and shifted to expansion strain under higher steam temperatures. Conclusions The equilibrium pressure of steam in the micropores of coals is below the saturated vapor pressure in a large space. A smaller pore size is associated with a lower pressure required for steam condensation and higher susceptibility to condensation-induced phase transition. The gas-liquid slug flow generated by steam in coals is identified as the main cause of the intermittent pulsation of steam permeability. Additionally, the inward and outward expansion effects are superimposed onto the influence of high-temperature steam on the permeability of coals, leading to decreased steam permeability of macropores but increased steam permeability of small pores within the matrix. During steam injection, the rapid expansion strain in the early stage is primarily dictated by pore pressure, while the slow expansion strain in the middle and late stages is predominantly subjected to the thermal strain induced by a temperature rise. The results of this study will provide a factual basis and theoretical reference for the engineering and numerical simulation of gas recovery via steam injection.

Keywords

gas, steam, temperature, two-phase seepage, thermal strain, heat injection

DOI

10.12363/issn.1001-1986.24.12.0830

Reference

[1] FANG Xiaojie,WU Caifang,ZHANG Hewei,et al. Stress distribution properties and deformation–fracture mechanisms in hydraulic fracturing of coal[J]. Fuel,2023,351:129049.

[2] 李国富,李超,张碧川,等. 我国煤矿瓦斯抽采与利用发展历程、技术进展及展望[J]. 煤田地质与勘探,2025,53(1):77−91.

LI Guofu,LI Chao,ZHANG Bichuan,et al. Gas drainage and utilization in coal mines in China:History,technological advances,and prospects[J]. Coal Geology & Exploration,2025,53(1):77−91.

[3] 薛彦平.低透气性煤层多孔同步分段水力压裂增透技术研究[J]. 煤炭工程,2024,56(6):111-116.

XUE Yanping. Segmented hydraulic fracturing technology by multi-hole synchronous drilling in low permeability coal seams[J]. Coal Engineering,2024,56(6):111-116.

[4] 苏现波,宋金星,郭红玉,等. 煤矿瓦斯抽采增产机制及关键技术[J]. 煤炭科学技术,2020,48(12):1−30.

SU Xianbo,SONG Jinxing,GUO Hongyu,et al. Increasing production mechanism and key technology of gas extraction in coal mines[J]. Coal Science and Technology,2020,48(12):1−30.

[5] 秦勇. 中国深部煤层气地质研究进展[J]. 石油学报,2023,44(11):1791−1811.

QIN Yong. Progress on geological research of deep coalbed methane in China[J]. Acta Petrolei Sinica,2023,44(11):1791−1811.

[6] NIE Bin. Development of low–metamorphic coalbed methane reservoirs with superheated steam injection:Simulation of wellbore heat transfer[J]. Energy,2023,275:127461.

[7] 石晓巅,冯子军. 真三轴应力下注蒸汽过程中无烟煤煤体内温度场分布规律研究[J]. 煤矿安全,2021,52(10):45−50.

SHI Xiaodian,FENG Zijun. Experimental study on temperature field distribution in anthracite during water vapour injection under triaxial pressure[J]. Safety in Coal Mines,2021,52(10):45−50.

[8] 孙朋. 基于孔–裂隙的煤层瓦斯抽采热–流–固耦合模型研究[J]. 矿业安全与环保,2024,51(4):64−73.

SUN Peng. Thermal–hydrological–solid coupling model of coal seam gas extraction based on pore–fracture[J]. Mining Safety & Environmental Protection,2024,51(4):64−73.

[9] 徐晓鹏,冯子军,董文强,等. 注高温过热水蒸汽条件下三轴受压无烟煤单裂缝渗流特性研究[J]. 矿业研究与开发,2022,42(10):19−24.

XU Xiaopeng,FENG Zijun,DONG Wenqiang,et al. Study on permeability characteristics of single fracture in the triaxially stressed anthracite subjected to high–temperature superheated steam injection[J]. Mining Research and Development,2022,42(10):19−24.

[10] 解镕嘉. 突出煤层密闭区域电热高温场影响因素及应用研究[D]. 贵阳:贵州大学,2021

[11] XIE Xionggang,YANG Jin,LUO Xiangying,et al. Numerical simulation of seepage–heat–solid coupling of gas seepage in prepumped boreholes under electrothermal high temperature field[J]. Geofluids,2022,2022(1):8706365.

[12] 杨新乐,姜涛,苏畅,等. 脉动微波循环注热开采煤层气数值模拟[J]. 微波学报,2021,37(4):89−94.

YANG Xinle,JIANG Tao,SU Chang,et al. Numerical simulation of coalbed methane extraction by pulsation cycle microwave heat injection[J]. Journal of Microwaves,2021,37(4):89−94.

[13] LAN Wenjian,WANG Hanxiang,LIU Qihu,et al. Investigation on the microwave heating technology for coalbed methane recovery[J]. Energy,2021,237:121450.

[14] 胡宜亮,鲍园,孟佳豪,等. 微波辐射时长对煤甲烷吸附效率的影响及机制[J]. 煤田地质与勘探,2025,53(3):90−98.

HU Yiliang,BAO Yuan,MENG Jiahao,et al. Influencing mechanisms of microwave radiation duration on the efficiency of methane adsorption in coals[J]. Coal Geology & Exploration,2025,53(3):90−98.

[15] 吕晓光,李伟. 多层砂岩油田热采油藏管理提高采收率[J]. 新疆石油地质,2024,45(1):65−71.

LYU Xiaoguang,LI Wei. Thermally recovered reservoir management and EOR for a multi–layered sandstone oilfield[J]. Xinjiang Petroleum Geology,2024,45(1):65−71.

[16] 杨新乐,张永利,杨英. 含瓦斯煤层注热温度场的数值模拟[J]. 西安科技大学学报,2009,29(3):282−286.

YANG Xinle,ZHANG Yongli,YANG Ying. Numerical simulation of temperature field on coalbed of gas with heat injection[J]. Journal of Xi’an University of Science and Technology,2009,29(3):282−286.

[17] 马玉林. 低渗透煤层煤层气注热开采过程的数值模拟[D]. 阜新:辽宁工程技术大学,2008.

MA Yulin. Numerical simulation of exploitation process through injection of heat into low permeability coal seam[D]. Fuxin:Liaoning Technical University,2008.

[18] SALMACHI A,HAGHIGHI M. Feasibility study of thermally enhanced gas recovery of coal seam gas reservoirs using geothermal resources[J]. Energy & Fuels,2012,26(8):5048−5059.

[19] TENG Teng,WANG J G,GAO Feng,et al. Complex thermal coal–gas interactions in heat injection enhanced CBM recovery[J]. Journal of Natural Gas Science and Engineering,2016,34:1174−1190.

[20] 唐明云,张亮伟,郑春山,等. 考虑蒸汽相变煤层气注热开采数值模拟研究[J]. 采矿与安全工程学报,2022,39(2):370−379.

TANG Mingyun,ZHANG Liangwei,ZHENG Chunshan,et al. Numerical simulation of coalbed methane production by heat injection considering steam condensation[J]. Journal of Mining & Safety Engineering,2022,39(2):370−379.

[21] 冯子军,万志军. 高温三轴应力下煤中甲烷生成特征及在注热开采瓦斯中应用[J]. 采矿与安全工程学报,2018,35(2):442−448.

FENG Zijun,WAN Zhijun. Methane release under triaxial stressed coal at high temperature and its application in methane extracting by heat injection[J]. Journal of Mining & Safety Engineering,2018,35(2):442−448.

[22] 李惟慷,杨新乐,张永利,等. 饱和蒸汽作用下煤体吸附甲烷运移产量规律试验研究[J]. 煤炭学报,2018,43(5):1343−1349.

LI Weikang,YANG Xinle,ZHANG Yongli,et al. Experimental study on migration yield law of coal-bed methane under the condition of saturated steam[J]. Journal of China Coal Society,2018,43(5):1343−1349.

[23] 杨凯. 热蒸汽注热作用下的煤体热响应特性及其增透效果的研究[D]. 徐州:中国矿业大学,2019.

YANG Kai. Study on the thermal response characteristics and permeability increasing effect of coal under hot steam heating[D]. Xuzhou:China University of Mining and Technology,2019.

[24] LI Yujie,ZHAI Cheng,XU Jizhao,et al. Feasibility investigation of enhanced coalbed methane recovery by steam injection[J]. Energy,2022,255:124473.

[25] 胡林杰,冯增朝,周动,等. 注热强化煤层气抽采的试验研究及工业应用[J]. 煤炭科学技术,2022,50(12):194−205.

HU Linjie,FENG Zengchao,ZHOU Dong,et al. Experimental research and industrial application of heat injection–enhanced coalbed methane extraction[J]. Coal Science and Technology,2022,50(12):194−205.

[26] 胡林杰,冯增朝,周动,等. 煤层气原位注热开采的数值模拟研究及工程实践[J]. 煤炭学报,2023,48(12):4473−4486.

HU Linjie,FENG Zengchao,ZHOU Dong,et al. Numerical simulation study and engineering practice of in–situ heat injection mining of coalbed methane[J]. Journal of China Coal Society,2023,48(12):4473−4486.

[27] LI Yujie,ZHAI Cheng,SUN Yong,et al. Characterizing water vapor adsorption on coal by nuclear magnetic resonance:Influence of coal pore structure and surface properties[J]. Energy,2023,282:128420.

[28] BRAUNER N,ULLMANN A. Modelling of flow pattern transitions in small diameter horizontal and inclined tubes[J]. Experimental Thermal and Fluid Science,2023,148:110965.

[29] GREGG S J. Adsorption,specific surface area,and porosity[M]. New York:Academic Press,1982.

[30] 李志强,鲜学福,隆晴明. 不同温度应力条件下煤体渗透率实验研究[J]. 中国矿业大学学报,2009,38(4):523−527.

LI Zhiqiang,XIAN Xuefu,LONG Qingming. Experiment study of coal permeability under different temperature and stress[J]. Journal of China University of Mining & Technology,2009,38(4):523−527.

[31] 张磊,杨世华,武晋宇,等. 有效应力下连续级配煤体的渗透特性试验[J]. 煤炭学报,2024,49(9):3872−3883.

ZHANG Lei,YANG Shihua,WU Jinyu,et al. Permeability characterization tests of continuous graded coal bodies under effective stresses[J]. Journal of China Coal Society,2024,49(9):3872−3883.

Share

COinS
 
 

To view the content in your browser, please download Adobe Reader or, alternately,
you may Download the file to your hard drive.

NOTE: The latest versions of Adobe Reader do not support viewing PDF files within Firefox on Mac OS and if you are using a modern (Intel) Mac, there is no official plugin for viewing PDF files within the browser window.