Convection - heat transfer coupling mechanism for closed-loop heat extraction from hydrothermal resources using horizontal wells

Authors

GU Feng, CNOOC Gas and Power Group, Beijing 100028, ChinaFollow
LI Youwu, CNOOC Gas and Power Group, Beijing 100028, China
ZHANG Yue, CNOOC Gas and Power Group, Beijing 100028, China
GAO Ying, CNOOC Gas and Power Group, Beijing 100028, China
YANG Peng, CNOOC Gas and Power Group, Beijing 100028, China
WANG Anran, CNOOC Gas and Power Group, Beijing 100028, China
CUI Jingyun, CNOOC Gas and Power Group, Beijing 100028, China

Abstract

Objective Closed-loop heat extraction technology, which extracts geothermal energy without draining geothermal water, has emerged as a research focus in geothermal energy exploitation. However, there is a lack of studies on the impacts of convection in reservoirs on heat transfer. Methods To improve single-well heat extraction, this study proposed a technology of closed-loop heat extraction from hydrothermal reservoirs using horizontal wells. This technology aims to increase the contact area between wellbores and reservoirs while fully leveraging the convection in reservoirs. A flow and heat transfer model characterized by the coupling of horizontal wells, circulating water and reservoirs was established to predict the heat extraction performance under natural/forced convection in hydrothermal reservoirs and reveal the evolutionary characteristics of the convective and temperature fields in reservoirs. Results and Conclusions Key findings are as follows: (1) The forced convection perpendicular to the horizontal section in the reservoirs can effectively alleviate the thermal breakthrough, significantly enhancing the heat extraction efficiency. Minor differences were observed in heat extraction under natural convection and forced convection parallel to the horizontal section. (2) Compared to the overburden, the reservoirs exhibited a predominant temperature increase of circulating water, with the temperature increment per meter being 2.4 times higher than that in the overburden. (3) The evolutionary processes of convective and temperature fields in the reservoirs were highly coupled. In the presence of only natural convection in the reservoirs, the temperature field variation range and the Darcy flow active zone were limited to areas near the wellbore, spreading along the radial direction. In the case where forced convection occurred, the temperature and convective fields were asymmetrically distributed on both sides of the horizontal wellbore, with the lower temperature zone and the lower Darcy velocity zone located in the downstream direction of the convection. (4) The dynamic temperature recovery of the reservoirs were governed by convection conditions. Forced convection can promote temperature recovery by accelerating the heat supply to areas around the wellbore, creating favorable conditions for long-term operation. The results of this study provide a reference for the research and design of a heat extraction system using horizontal wells.

Keywords

hydrothermal resource, horizontal well, closed-loop heat extraction, convection-heat transfer coupling, natural convection, forced convection

DOI

10.12363/issn.1001-1986.23.11.0730

Recommended Citation

GU Feng, LI Youwu, ZHANG Yue, et al. (2024) "Convection - heat transfer coupling mechanism for closed-loop heat extraction from hydrothermal resources using horizontal wells," Coal Geology & Exploration: Vol. 52: Iss. 9, Article 12.
DOI: 10.12363/issn.1001-1986.23.11.0730
Available at: https://cge.researchcommons.org/journal/vol52/iss9/12

Reference

[1] 2023第七届世界地热大会. 中国地热直接利用规模居世界首位. [EB/OL]. http://jx.people.com.cn/n2/2023/0918/c186330-40574420.html. 2024-03-18.

[2] 何淼，龚武镇，许明标，等. 干热岩开发技术研究现状与展望分析[J]. 可再生能源，2021，39(11)：1447−1454.

HE Miao，GONG Wuzhen，XU Mingbiao，et al. Research status and prospect analysis of hot dry rock development technology[J]. Renewable Energy Resources，2021，39(11)：1447−1454.

[3] 王贵玲，刘彦广，朱喜，等. 中国地热资源现状及发展趋势[J]. 地学前缘，2020，27(1)：1−9.

WANG Guiling，LIU Yanguang，ZHU Xi，et al. The status and development trend of geothermal resources in China[J]. Earth Science Frontiers，2020，27(1)：1−9.

[4] 曹倩，方朝合，李云，等. 国内外地热回灌发展现状及启示[J]. 石油钻采工艺，2021，43(2)：203−211.

CAO Qian，FANG Chaohe，LI Yun，et al. Development status of geothermal reinjection at home and abroad and its enlightenment[J]. Oil Drilling & Production Technology，2021，43(2)：203−211.

[5] 许勇. 西安三桥地区孔隙型地热尾水回灌模拟及前景展望[D]. 西安：长安大学，2018.

XU Yong. Simulation and Prospect of Pore Type Geothermal Tail Water Reinjection in Sanqiao District of Xi’an：A cases study of geothermal reinjection wells of Huisen company[D]. Xi’an：Chang’an University，2018.

[6] 赵军，宋超凡，尹洪梅，等. 越流型单井系统含水层渗流传热规律研究[J]. 天津大学学报(自然科学与工程技术版)，2023，56(4)：333−345.

ZHAO Jun，SONG Chaofan，YIN Hongmei，et al. Investigating the seepage and heat transfer law of aquifers in the leaky type single-well system[J]. Journal of Tianjin University (Science and Technology)，2023，56(4)：333−345.

[7] 许天福，姜振蛟，袁益龙. 中深部地热资源开发利用研究现状与展望[J]. 中国基础科学，2023，25(3)：11−22.

XU Tianfu，JIANG Zhenjiao，YUAN Yilong. Research status and prospects of middle and deep geothermal resources exploitation and utilization[J]. China Basic Science，2023，25(3)：11−22.

[8] HORNE R N. Design considerations of a down-hole coaxial geothermal heat exchanger[J]. Geothermal Resources Council，1980，4：569−572.

[9] KOHL T，BRENNI R，EUGSTER W. System performance of a deep borehole heat exchanger[J]. Geothermics，2002，31(6)：687−708.

[10] 邓杰文，彭晨玮，朱超，等. 中深层地埋管热泵供热系统运行特性实测研究[J]. 暖通空调，2024，54(4)：113−119.

DENG Jiewen，PENG Chenwei，Zhu Chao，et al. Field test and analysis on operation characteristics of medium-depth buried pipe heat pump heating systems[J]. Journal of HV& AC，2024，54(4)：113−119.

[11] LUO Yongqiang，GUO Hongshan，MEGGERS F，et al. Deep coaxial borehole heat exchanger：Analytical modeling and thermal analysis[J]. Energy，2019，185：1298−1313.

[12] 焦开拓，孙成珍，白博峰，等. 地下水渗流对中深层地埋管取热性能的影响规律[J]. 天然气工业，2022，42(4)：85−93.

JIAO KaiTuo，SUN Chengzhen，BAI Bofeng，et al. Effect of groundwater advection on heat transfer performance of deep borehole heat exchangers[J]. Natural Gas Industry，2022，42(4)：85−93.

[13] 张哲菲，刘洪涛，刘攀峰，等. 中深层地热地埋管实际运行影响因素研究[J]. 太阳能学报，2022，43(12)：503−509.

ZHANG Zhefei，LIU Hongtao，LIU Panfeng，et al. Study on actual operation and influencing factors of middle-deep geothermal buried pipe[J]. Acta Energiae Solaris Sinica，2022，43(12)：503−509.

[14] LE LOUS M，LARROQUE F，DUPUY A，et al. Thermal performance of a deep borehole heat exchanger：Insights from a synthetic coupled heat and flow model[J]. Geothermics，2015，57：157−172.

[15] ZANCHINI E，LAZZARI S，PRIARONE A. Improving the thermal performance of coaxial borehole heat exchangers[J]. Energy，2010，35(2)：657−666.

[16] 邹海江，李永鹏，张林，等. 陕北地区中深层同轴地埋管取热性能影响因素分析及优化[J]. 煤田地质与勘探，2024，52(1)：152−158.

ZOU Haijiang，LI Yongpeng，ZHANG Lin，et al. Influencing factor analysis and optimization of heat extraction performance of moderately deep coaxial borehole heat exchangers in Northern Shaanxi，China[J]. Coal Geology & Exploration，2024，52(1)：152−158.

[17] 李奉翠，韩二帅，梁磊，等. 中深层地热井下同轴换热器长期换热性能研究[J]. 煤田地质与勘探，2021，49(2)：194−201.

LI Fengcui，HAN Ershuai，LIANG Lei，et al. Long-term heat transfer performance of underground coaxial heat exchanger for medium-deep geothermal[J]. Coal Geology & Exploration，2021，49(2)：194−201.

[18] 王沣浩，蔡皖龙，王铭，等. 地热能供热技术研究现状及展望[J]. 制冷学报，2021，42(1)：14−22.

WANG Fenghao，CAI Wanlong，WANG Ming，et al. Status and outlook for research on geothermal heating technology[J]. Journal of Refrigeration，2021，42(1)：14−22.

[19] WANG Zhihua，WANG Fenghao，LIU Jun，et al. Field test and numerical investigation on the heat transfer characteristics and optimal design of the heat exchangers of a deep borehole ground source heat pump system[J]. Energy Conversion and Management，2017，153：603−615.

[20] HUANG Yibin，ZHANG Yanjun，XIE Yangyang，et al. Thermal performance analysis on the composition attributes of deep coaxial borehole heat exchanger for building heating[J]. Energy and Buildings，2020，221：110019.

[21] SONG Xianzhi，ZHENG Rui，LI Gensheng，et al. Heat extraction performance of a downhole coaxial heat exchanger geothermal system by considering fluid flow in the reservoir[J]. Geothermics，2018，76：190−200.

[22] ZHANG Liang，YANG Linchao，GENG Songhe，et al. Numerical simulation on the heat extraction from the porous medium-low temperature geothermal reservoirs by self-circulation wellbore and its enhanced methods[J]. Renewable Energy，2022，194：1009−1025.

[23] KANG Wenkai，LIU Feng，YANG Feifan，et al. Simulation of heat transfer performance using middle-deep coaxial borehole heat exchangers by FEFLOW[J]. Journal of Groundwater Science and Engineering，2020，8(4)：315−327.

[24] GU Feng，LI Youwu，TANG Dazhen，et al. Heat extraction performance of horizontal-well deep borehole heat exchanger and comprehensive comparison with the vertical well[J]. Applied Thermal Engineering，2022，211：118426.

[25] CHURCHILL S W. Friction-factor equation spans all fluid-flow regimes[J]. Mechanical Engineering (NY)，1977，84：91−92.

[26] GNIELINSKI V. New equations for heat and mass transfer in turbulent pipe and channel flow[J]. Mechanical Engineering，1976，16(2)：8−16.

[27] LINSTROM P J，MALLARD W G. The NIST chemistry WebBook：A chemical data resource on the Internet[J]. Journal of Chemical & Engineering Data，2001，46(5)：1059−1063.

[28] WANG Gaosheng，SONG Xianzhi，SONG Guofeng，et al. Analyzes of thermal characteristics of a hydrothermal coaxial closed-loop geothermal system in a horizontal well[J]. International Journal of Heat and Mass Transfer，2021，180：121755.

[29] MORITA K，YAMAGUCHI T，KARASAWA H，et al. Development and evaluation of temperature simulation code for geothermal wells[J]. Journal of the Mining and Metallurgical Institute of Japan，1984，100(1161)：1045−1051.

[30] MORITA K，BOLLMEIER W S，MIZOGAMI H. Analysis of the results from the downhole coaxial heat exchanger (DCHE) experiment in Hawaii[J]. Geothermal Resources Council，1992，16：17−23.