A simulation study on the formation mechanisms of gas hydrates in pores of gas hydrate-bearing sediments in the South China Sea

Authors

ZHENG Mingming, State Key Laboratory of Geohazard Prevention and Geoenvironment Protection, Chengdu University of Technology, Chengdu 610059, China; Key Laboratory of Gas Hydrate, Chinese Academy of Sciences (Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences), Guangzhou 510640, ChinaFollow
ZHOU Kerui, State Key Laboratory of Geohazard Prevention and Geoenvironment Protection, Chengdu University of Technology, Chengdu 610059, China
WU Zurui, State Key Laboratory of Geohazard Prevention and Geoenvironment Protection, Chengdu University of Technology, Chengdu 610059, China
LIU Tianle, Engineering Research Center of Rock-Soil Drilling & Excavation and Protection of Ministry of Education, China University of Geosciences (Wuhan), Wuhan 430074, ChinaFollow
YAN Shichun, State Key Laboratory of Geohazard Prevention and Geoenvironment Protection, Chengdu University of Technology, Chengdu 610059, China
ZENG Guo’ao, State Key Laboratory of Geohazard Prevention and Geoenvironment Protection, Chengdu University of Technology, Chengdu 610059, China

Abstract

The formation of high-quality gas hydrates in the pores of the sediment matrix serves as the premise and material basis for experimental research on gas hydrates, thus providing theoretical guidance for the exploration of deep-water hydrocarbons and gas hydrates in China. Based on the geological conditions of gas hydrate-bearing sediments in well GMGS2-07 in the South China Sea, this study conducted numerical simulations and laboratory experiments using the TOUGH+HYDRATE code and a self-developed device for gas hydrate reactions and generation, respectively. Firstly, this study verified the accuracy and reliability of the numerical simulation method. Then, it investigated the quality of gas hydrates generated under different thermal conductivities and water saturation of sediments to determine their influencing mechanisms. The results are as follows: (1) Both numerical simulations and laboratory experiments yielded consistent variation trends and nearly identical characteristic values of the temperature, pressure, and three-phase materials in the process of gas hydrate formation. Therefore, the numerical simulation method used in this study is accurate and reliable; (2) A higher thermal conductivity was associated with faster gas hydrate formation, as well as the higher saturation and more uniform distribution of the final gas hydrates. However, the correlation between the thermal conductivity and the final gas hydrate saturation depended on the position relative to critical boundaries, which were determined at a distance of 1.8 cm from the upper and right boundaries of the tank reactor used in this study. There was a positive correlation between the thermal conductivity and the gas hydrate saturation within the critical boundaries. Otherwise, they were negatively correlated. The distances between the critical boundaries and the boundaries of the water bath increased with an increase in the tank reactor size but were not affected by the formation permeability; (3) As the formation water saturation increased, the saturation of the final gas hydrates first increased and then decreased, and the peak water saturation was less than the theoretical gas-water ratio under the initial pressure. The gas hydrates showed the highest saturation and the most ununiform distribution when the initial pressure was 7.8 MPa and the water saturation was about 22.23%. Therefore, the sediment matrix prepared using high-thermal-conductivity materials, the initial water saturation lower than the theoretical gas-water ratio, and the initial temperature and pressure falling to the left of the phase equilibrium curve are conducive to the formation of high-saturation, uniformly distributed gas hydrates. This study will provide a sound material basis for well cementing in deep-water sediments bearing hydrocarbons and gas hydrates, as well as the drilling and exploitation of gas hydrate resources. Moreover, it will contribute to the technical preparation for the commercial recovery of gas hydrates.

Keywords

South China Sea, natural gas hydrate, laboratory experiment, thermal conductivity, water saturation, TOUGH+HYDRATE

DOI

10.12363/issn.1001-1986.22.12.0925

Recommended Citation

ZHENG Mingming, ZHOU Kerui, WU Zurui, et al. (2023) "A simulation study on the formation mechanisms of gas hydrates in pores of gas hydrate-bearing sediments in the South China Sea," Coal Geology & Exploration: Vol. 51: Iss. 5, Article 7.
DOI: 10.12363/issn.1001-1986.22.12.0925
Available at: https://cge.researchcommons.org/journal/vol51/iss5/7

Reference

[1] SLOAN E D，KOH C A. Clathrate hydrates of natural gases[M]. London：CRC Press，2007.

[2] MALAGAR B R C,LIJITH K P,SINGH D N. Formation & dissociation of methane gas hydrates in sediments:A critical review[J]. Journal of Natural Gas Science and Engineering,2019,65:168−184.

[3] 许红,黄君权,夏斌,等. 最新国际天然气水合物研究现状与资源潜力评估(上)[J]. 天然气工业,2005,25(5):21−25.

XU Hong,HUANG Junquan,XIA Bin,et al. Current research situation and resource potential evaluation of natural gas hydrate in the world[J]. Natural Gas Industry,2005,25(5):21−25.

[4] ZHAO Jiafei,LIU Yanzhen,YANG Lei,et al. Organics–coated nano clays further promote hydrate formation kinetics[J]. The Journal of Physical Chemistry Letters,2021,12(13):3464−3467.

[5] CHEN Zherui,LI Yanghui,CHEN Cong,et al. Aggregation behavior of asphalt on the natural gas hydrate surface with different surfactant coverages[J]. The Journal of Physical Chemistry C,2021,125(30):16378−16390.

[6] PAULL C K,USSLER W,BOROWSKI W S,et al. Methane–rich plumes on the Carolina continental rise:Associations with gas hydrates[J]. Geology,1995,23(1):89−92.

[7] 祝有海,庞守吉,王平康,等. 中国天然气水合物资源潜力及试开采进展[J]. 沉积与特提斯地质,2021,41(4):524−535.

ZHU Youhai,PANG Shouji,WANG Pingkang,et al. A review of the resource potentials and test productions of natural gas hydrates in China[J]. Sedimentary Geology and Tethyan Geology,2021,41(4):524−535.

[8] LI Qingchao,CHENG Yuanfang,LI Qiang,et al. Investigation method of borehole collapse with the multi–field coupled model during drilling in clayey silt hydrate reservoirs[J]. Fracture and Structural Integrity,2018,12(45):86−99.

[9] LI Lijia,LUO Yongjiang,PENG Jianming,et al. Theoretical analysis of the influence of drilling compaction on compressional wave velocity in hydrate−bearing sediments[J]. Energy Science & Engineering,2019,7(2):420−430.

[10] ZHENG Mingming,LIU Tianle,JIANG Guosheng,et al. Large–scale and high–similarity experimental study of the effect of drilling fluid penetration on physical properties of gas hydrate–bearing sediments in the Gulf of Mexico[J]. Journal of Petroleum Science and Engineering,2020,187:106832.

[11] 郑明明,王晓宇,周珂锐,等. 深水油气固井水合物储层物性响应与高压气水反侵研究[J]. 煤田地质与勘探,2021,49(3):118−127.

ZHENG Mingming,WANG Xiaoyu,ZHOU Kerui,et al. Hydrate reservoir physical properties response and high−pressure gas–water reverse penetration during deepwater oil and gas cementing[J]. Coal Geology & Exploration,2021,49(3):118−127.

[12] 宁伏龙,方翔宇,李彦龙,等. 天然气水合物开采储层出砂研究进展与思考[J]. 地质科技通报,2020,39(1):137−148.

NING Fulong,FANG Xiangyu,LI Yanlong,et al. Research status and perspective on wellbore sand production from hydrate reservoirs[J]. Bulletin of Geological Science and Technology,2020,39(1):137−148.

[13] WANG Bin,DONG Hongsheng,FAN Zhen,et al. Numerical analysis of microwave stimulation for enhancing energy recovery from depressurized methane hydrate sediments[J]. Applied Energy,2020,262:114559.

[14] WANG Yi,KOU Xuan,FENG Jingchun,et al. Sediment deformation and strain evaluation during methane hydrate dissociation in a novel experimental apparatus[J]. Applied Energy,2020,262:114397.

[15] 郑明明,王晓宇,周珂锐,等. 南海水合物储层固井过程高压气水反侵临界条件判别[J]. 中南大学学报 (自然科学版),2022,53(3):963−975.

ZHENG Mingming,WANG Xiaoyu,ZHOU Kerui,et al. Critical conditions identification of generated high−pressure gas and water reverse penetration during cementing in hydrate reservoirs in the South China Sea[J]. Journal of Central South University (Science and Technology),2022,53(3):963−975.

[16] 郑明明,蒋国盛,刘天乐,等. 钻井液侵入时水合物近井壁地层物性响应特征[J]. 地球科学,2017,42(3):453−461.

ZHENG Mingming,JIANG Guosheng,LIU Tianle,et al. Physical properties response of hydrate bearing sediments near wellbore during drilling fluid invasion[J]. Earth Science,2017,42(3):453−461.

[17] LI Bo,LIU Shengdong,LIANG Yunpei,et al. The use of electrical heating for the enhancement of gas recovery from methane hydrate in porous media[J]. Applied Energy,2018,227:694−702.

[18] 刘军,马贵阳,潘振,等. 甲烷水合物生成分解的实验研究[J]. 化学工程,2015,43(11):35−40.

LIU Jun,MA Guiyang,PAN Zhen,et al. Experiment on formation and decomposition of methane hydrate[J]. Chemical Engineering,2015,43(11):35−40.

[19] FENG Jingchun,LI Bo,LI Xiaosen,et al. Effects of depressurizing rate on methane hydrate dissociation within large–scale experimental simulator[J]. Applied Energy,2021,304:117750.

[20] GAJANAYAKE S,GAMAGE R P,WANNIARACHIGE P. The influence of confining stresses on formation kinetics of methane gas hydrates[J]. Fuel,2022,316:123257.

[21] GE Binbin,ZHONG Dongliang,LU Yiyu. Influence of water saturation and particle size on methane hydrate formation and dissociation in a fixed bed of silica sand[J]. Energy Procedia,2019,158:5402−5407.

[22] 王英梅,董世强,展静,等. 石英砂粒径大小对甲烷水合物形成及分布的影响[J]. 化工进展,2020,39(8):3049−3056.

WANG Yingmei,DONG Shiqiang,ZHAN Jing,et al. Effect of quartz sand particle size on the formation and distribution of methane hydrate[J]. Chemical Industry and Engineering Progress,2020,39(8):3049−3056.

[23] CHONG Zhengrong,CHAN A H M,BABU P,et al. Effect of NaCl on methane hydrate formation and dissociation in porous media[J]. Journal of Natural Gas Science and Engineering,2015,27:178−189.

[24] ESMAIL S,BELTRAN J G. Methane hydrate propagation on surfaces of varying wettability[J]. Journal of Natural Gas Science and Engineering,2016,35:1535−1543.

[25] 张雯翔. 介质孔隙中水合物形成与分解机制研究[D]. 广州：华南理工大学，2018.

ZHANG Wenxiang. Study on the hydrate formation and dissociation mechanism in porous media[D]. Guangzhou：South China University of Technology，2018.

[26] 张光学,陈芳,沙志彬,等. 南海东北部天然气水合物成藏演化地质过程[J]. 地学前缘,2017,24(4):15−23.

ZHANG Guangxue,CHEN Fang,SHA Zhibin,et al. The geological evolution process of natural gas hydrate reservoirs in the northeastern South China Sea[J]. Earth Science Frontiers,2017,24(4):15−23.

[27] 沙志彬. 南海东北部海域XN区块天然气水合物资源综合预测与评价[D]. 武汉：中国地质大学，2019.

SHA Zhibin. Integrated prediction and evaluation for natural gas hydrate resource of XN study area in the northeastern South China Sea[D]. Wuhan：China University of Geosciences，2019.

[28] HUANG Li,YIN Zhenyuan,WAN Yizhao,et al. Evaluation and comparison of gas production potential of the typical four gas hydrate deposits in Shenhu Area,South China Sea[J]. Energy,2020,204:117955.

[29] 张光学,黄永样,祝有海,等. 南海天然气水合物的成矿远景[J]. 海洋地质与第四纪地质,2002,22(1):75−81.

ZHANG Guangxue,HUANG Yongyang,ZHU Youhai,et al. Prospect of gas hydrate resources in the South China Sea[J]. Marine Geology and Quaternary Geology,2002,22(1):75−81.

[30] 梁金强,王宏斌,苏新,等. 南海北部陆坡天然气水合物成藏条件及其控制因素[J]. 天然气工业,2014,34(7):128−135.

LIANG Jinqiang,WANG Hongbin,SU Xin,et al. Natural gas hydrate formation conditions and the associated controlling factors in the northern slope of the South China Sea[J]. Natural Gas Industry,2014,34(7):128−135.

[31] KURIHARA M,SATO A,FUNATSU K,et al. Analysis of formation pressure test results in the Mount Elbert methane hydrate reservoir through numerical simulation[J]. Marine and Petroleum Geology,2011,28(2):502−516.

[32] MORIDIS G J. Tough+hydrate v1. 2 user’s manual：A code for the simulation of system behavior in hydrate–bearing geologic media[EB/OL]. Berkeley：Lawrence Berkeley National Laboratory，2014. //http://escholarship.org/uc/item/3mk82656.

[33] STONE H L. Probability model for estimating three–phase relative permeability[J]. Journal of Petroleum Technology,1970,22(2):214−218.

[34] MORIDIS G J，SEOL Y，KNEAFSEY T J. Studies of reaction kinetics of methane hydrate dissociation in porous media[EB/OL]. Berkeley：Lawrence Berkeley National Laboratory，2005. //https://escholarship.org/uc/item/8q50w5cn.

[35] MORIDIS G J. Numerical studies of gas production from methane hydrates[J]. SPE Journal,2003,8(4):359−370.

[36] LI Xiaoyan,FENG Jingchun,LI Xiaosen,et al. Experimental study of methane hydrate formation and decomposition in the porous medium with different thermal conductivities and grain sizes[J]. Applied Energy,2020,305:117852.

[37] 程传晓. 天然气水合物沉积物传热特性及对开采影响研究[D]. 大连理工大学(大连), 2015.

CHENG Chuanxiao. Study of heat transfer characteristic and the effects on exploitation for natural gas hydrate sediments[D]. Dalian University of Technology(Dalian), 2015.