Molecular simulation of the effect of CO₂/N₂ binary gas on methane adsorption in coal

Authors

SUN Zhixue, School of Petroleum Engineering, China University of Petroleum(East China), Qingdao 266580, ChinaFollow
MIN Cheng, School of Petroleum Engineering, China University of Petroleum(East China), Qingdao 266580, China
ZHANG Wanlu, School of Petroleum Engineering, China University of Petroleum(East China), Qingdao 266580, China
JIANG Yongping, Linfen Coalbed Methane Branch, SINOPEC, Linfen 041000, China
YU Xuefeng, Linfen Coalbed Methane Branch, SINOPEC, Linfen 041000, China
CUI Bin, Linfen Coalbed Methane Branch, SINOPEC, Linfen 041000, China

Abstract

The binary gas flooding technology (CO₂/N₂-ECBM) has become an important means of increasing the production of coalbed methane(CBM). It is of great significance to clarify the CO₂/N₂ competitive adsorption law in coal seams and its influence on the physical properties of coal seams. The molecular simulation software Materials Studio was used to establish a coal molecular model according to the actual temperature and pressure of the CBM block in Yanchuannan. On the basis of the Grand Canonical Monte Carlo(GCMC) method, the influence of each injection stage in the technology of CO₂/N₂ alternate displacement of CBM on the adsorption of CH₄ was studied, and the law of the influence of CO₂ and N₂ on the porosity and permeability of coal seams was clarified. The results show that during the CO₂ injection stage, the methane in the coal seam is rapidly desorbed, and due to the increase of the total amount of gas adsorbed in the coal seam, the coal matrix swelling effect enhances, which leads to a reduction in the pore volume of the coal. During the N₂ injection, the adsorption of CH₄ and CO₂ shows different degrees of reduction due to the partial pressure of N₂. The total adsorption amount of gas in coal molecules decreases rapidly when ω_N2/ω_CO2≤0.6, while it remains stable after the saturated adsorption of N₂. With the total amount of gas adsorption, the porosity and permeability of the coal seam show a rapid increase and then tend to be flat. In addition, the N₂ adsorption rate decreases rapidly after the ω_N2/ω_CO2>0.6, which makes the purity of the CH₄ lower in the produced gas, resulting in a large increase in the cost of later purification. Therefore, when ω_N2/ω_CO2=0.6, the amount of CH₄ desorption is the maximum and the coal porosity is relatively high, which is most conducive to CBM development.

Funding Information

10.12363/issn.1001-1986.21.11.0657

Keywords

CO2/N2 competitive adsorption, molecular simulation, coalbed methane, porosity, permeability, Southern Yanchuan Block

Recommended Citation

SUN Zhixue, MIN Cheng, ZHANG Wanlu, et al. (2022) "Molecular simulation of the effect of CO₂/N₂ binary gas on methane adsorption in coal," Coal Geology & Exploration: Vol. 50: Iss. 3, Article 14.
Available at: https://cge.researchcommons.org/journal/vol50/iss3/14

Reference

[1] 桑树勋. 二氧化碳地质存储与煤层气强化开发有效性研究述评[J]. 煤田地质与勘探,2018,46(5):1−9. SANG Shuxun. Research review on technical effectiveness of CO₂ geological storage and enhanced coalbed methane recovery[J]. Coal Geology & Exploration,2018,46(5):1−9.

[2] YAO Yanbin,LIU Dameng,CAI Yidong,et al. Advanced characterization of pores and fractures in coals by nuclear magnetic resonance and X−ray computed tomography[J]. Science China(Earth Sciences),2010,53(6):854−862.

[3] 毛安妮. 低渗透煤储层煤层气开采有效技术途径的研究[J]. 中国石油和化工标准与质量,2017,37(8):65−66. MAO Anni. Research on effective technical approaches for coal bed methane exploitation in low permeability coal reservoirs[J]. China Petroleum and Chemical Standard and Quality,2017,37(8):65−66.

[4] 陈贞龙. 延川南深部煤层气田地质单元划分及开发对策[J]. 煤田地质与勘探,2021,49(2):13−20. CHEN Zhenlong. Geological unit division and development countermeasures of deep coalbed methane in southern Yanchuan Block[J]. Coal Geology & Exploration,2021,49(2):13−20.

[5] 陈晨,何邢益,牛庆合,等. 超临界CO₂ 注入煤层对顶板岩石纵波速度及力学响应特征研究[J]. 煤田地质与勘探,2021,49(5):98−104. CHEN Chen,HE Xingyi,NIU Qinghe,et al. Study on P−wave velocity and mechanical response characteristic of rock in coal seam roof with supercritical CO₂ injection[J]. Coal Geology & Exploration,2021,49(5):98−104.

[6] 刘兴浩,李志臻,杨旭,等. 泡沫压裂液在煤层气开采中的伤害性评价及分析[J]. 钻井液与完井液,2013,30(4):69−71. LIU Xinghao,LI Zhizhen,YANG Xu,et al. Damage evaluation and analysis of foam fracturing fluid in CBM production[J]. Drilling Fluid & Completion Fluid,2013,30(4):69−71.

[7] 李超飞. 屯兰2#煤与压裂液相互作用机制的实验与分子模拟[D]. 太原：太原理工大学，2019.

LI Chaofei. Experimental and molecular simulation of the interaction mechanism between Tunlan 2# coal and fracturing fluid[D]. Taiyuan：Taiyuan University of Technology，2019.

[8] 安世岗,陈殿赋,张永民,等. 可控电脉冲波增透技术在低透气性煤层中的应用[J]. 煤田地质与勘探,2020,48(4):138−145. AN Shigang,CHEN Dianfu,ZHANG Yongmin,et al. Application of controllable electric pulse wave permeability–enhancing technology in the low–permeability coal seams[J]. Coal Geology & Exploration,2020,48(4):138−145.

[9] ZHANG Jiyuan,FENG Qihong,ZHANG Xianmin,et al. A two−stage step−wise framework for fast optimization of well placement in coalbed methane reservoirs[J]. International Journal of Coal Geology,2020,225:103479.

[10] 段伟伟,张全盛,赵建新. 煤层气多分支水平井钻井工艺分析[J]. 内蒙古煤炭经济,2019(20):54. DUAN Weiwei,ZHANG Quansheng,ZHAO Jianxin. Drilling technology analysis of multi–branch horizontal wells for coalbed methane[J]. Inner Mongolia Coal Economy,2019(20):54.

[11] GODEC M,KOPERNA G,PETRUSAK R,et al. Potential for enhanced gas recovery and CO₂ storage in the Marcellus Shale in the Eastern United States[J]. International Journal of Coal Geology,2013,118:95−104.

[12] PAN Zhejun,CONNELL L D. Modelling permeability for coal reservoirs:A review of analytical models and testing data[J]. International Journal of Coal Geology,2012,92:1−44.

[13] 桑树勋，牛庆合，曹丽文，王伟．深部煤层CO₂注入煤岩力学响应特征及机理 研究进展[J/OL]. 地球科学，2021：1-16[2021-12-28]. https://kns.cnki.net/kcms/detail/42.1874.P.20211228.1028.010.html.

SANG Shuxun, NIU Qinghe, CAO Liwen, et al. Mechanical Response Characteristic and Mechanism of Coal-rock with CO₂ Injection in Deep Coal Seam: A Review[J/OL]. Earth Science，2021：1-16[2021-12-28]. https://kns.cnki.net/kcms/detail/42.1874.P.20211228.1028.010.html

[14] 贾金龙. 超临界CO₂注入无烟煤储层煤岩应力应变效应的实验模拟研究[D]. 北京：中国矿业大学，2016.

JIA Jinlong. Experimental simulation on stress and strain effects as supercritical CO₂ being injected into deep anthracite reservoirs[D]. Beijing：China University of Mining and Technology，2016.

[15] MAVOR M J,GUNTER W D,ROBINSON J R. Alberta multiwell micro–pilot testing for CBM properties,enhanced methane recovery and CO₂ storage potential[J]. September Paper presented at the SPE Annual Technical Conference and Exhibition,Houston. SPE 90256,2004:26−29.

[16] 方志明. 混合气体驱替煤层气技术的机理及试验研究[D]. 武汉：中国科学院武汉岩土力学研究所，2009.

FANG Zhiming. Mechanisms and experimental study of gas mixture enhanced coalbed methane recovery technology[D]. Wuhan：Institute of Rock and Soil Mechanics，the Chinese Academy of Sciences，2009.

[17] MAZZOTTI M,PINI R,STORTI G. Enhanced coalbed methane recovery[J]. The Journal of Supercritical Fluids,2009,47(3):619−627.

[18] TENNEY C M. Molecular simulation of carbon dioxide adsorption for carbon capture and storage[J]. Environmental Progress,2006,25(4):343−354.

[19] LIU Yangyang,WILCOX J. Effects of surface heterogeneity on the adsorption of CO₂ in microporous carbons[J]. Environmental Science & Technology,2012,46(3):1940−1947.

[20] 刘宇. 煤镜质组结构演化对甲烷吸附的分子级作用机理[D]. 北京：中国矿业大学，2019.

LIU Yu. Effect of coal vitrinite macromolecular structure evolution on methane adsorption capacity at molecular level[D]. Beijing：China University of Mining and Technology，2019.

[21] NARKIEWICZ M R,MATHEWS J P. Visual representation of carbon dioxide adsorption in a low–volatile bituminous coal molecular model[J]. Energy & Fuels,2009,23(10):5236−5246.

[22] 周来诚. 煤岩气藏注入CO₂/N₂实验及数值模拟研究[D]. 成都：西南石油大学，2015.

ZHOU Laicheng. CO₂/N₂ injection experiment and numerical simulation study on coal gas reservoir[D]. Chengdu：Southwest Petroleum University，2015.

[23] 赵景辉,高玉巧,陈贞龙,等. 鄂尔多斯盆地延川南区块深部地应力状态及其对煤层气开发效果的影响[J]. 中国地质,2021,48(3):785−793. ZHAO Jinghui,GAO Yuqiao,CHEN Zhenlong,et al. Stress state of deep seam and its influence on development performance of CBM wells in South Yanchuan Block,Ordos Basin[J]. Geology in China,2021,48(3):785−793.

[24] 张海荣. 鄂尔多斯盆地延川南区块主力煤层煤岩储层特征研究及产能影响因素分析[D]. 西安：西北大学，2012.

ZHANG Hairong. Study on reservoir characteristics of main coal seam in Yanchuan South block，Ordos Basin and analysis on influencing factors of productivity[D]. Xi’an：Northwest University，2012.

[25] 严煌. 无烟煤分子结构特征及热解过程中官能团迁移特性研究[D]. 徐州：中国矿业大学，2019.

YAN Huang. Study on the characteristics of anthracite molecular structure and the variation of functional groups during pyrolysis[D]. Xuzhou：China University of Mining and Technology，2019.

[26] GELB L D,GUBBINS K E. Pore size distributions in porous glasses:A computer simulation study[J]. Langmuir,1999,15(2):305−308.

[27] LIU Jishan,CHEN Zhongwei,ELSWORTH D,et al. Interactions of multiple processes during CBM extraction:A critical review[J]. International Journal of Coal Geology,2011,87(3-4):175−189.

[28] 杨宏民,梁龙辉. 等压扩散下CO₂对不同变质程度煤中CH₄置换效应的影响[J]. 煤田地质与勘探,2018,46(5):55−59. YANG Hongmin,LIANG Longhui. Influence of CO₂ on the replacement effect of CH₄ in coal of different metamorphic grade under isobaric diffusion[J]. Coal Geology & Exploration,2018,46(5):55−59.

[29] 刘会虎,吴海燕,徐宏杰,等. 沁水盆地南部深部煤层超临界 CO₂ 吸附特征及其控制因素[J]. 煤田地质与勘探,2018,46(5):37−42. LIU Huihu,WU Haiyan,XU Hongjie,et al. Supercritical CO₂ adsorption characteristics and their control factors in deep–seated coal seams in southern Qinshui Basin[J]. Coal Geology & Exploration,2018,46(5):37−42.

[30] 牛庆合,曹丽文,周效志. CO₂注入对煤储层应力应变与渗透率影响的实验研究[J]. 煤田地质与勘探,2018,46(5):43−48. NIU Qinghe,CAO Liwen,ZHOU Xiaozhi. Experimental study of the influences of CO₂ injection on stress–strain and permeability of coal reservoir[J]. Coal Geology & Exploration,2018,46(5):43−48.

[31] QU Hongyan,LIU Jishan,CHEN Zhongwei,et al. Complex evolution of coal permeability during CO₂ injection under variable temperatures[J]. International Journal of Greenhouse Gas Control,2012,9:281−293.

[32] OUDINOT A,KOPERNA G,PHILIP Z G,et al. CO₂ injection performance in the fruitland coal fairway,San Juan Basin:Results of a field pilot[J]. SPE,2011,16(4):864−879.

[33] WEI Xiaorong,MASSAROTTO P,WANG G,et al. CO₂ sequestration in coals and enhanced coalbed methane recovery:New numerical approach[J]. Fuel,2010,89(5):1110−1118.

[34] KIYAMA T,NISHIMOTO S,FUJIOKA M,et al. Coal swelling strain and permeability change with injecting liquid/supercritical CO₂ and N₂ at stress−constrained conditions[J]. International Journal of Coal Geology,2011,85(1):56−64.