Main influencing factors for regional pre-grouting technology of water hazard treatment in coal seam floor and efficient hole arrangement

Authors

HU Weiyue, Xi’an Research Institute (Group) Co. Ltd., China Coal Technology and Engineering Group Corp., Xi’an 710077, China; Shaanxi Key Laboratory of Preventing and Controlling Technology for Coal Mine Water Hazard, Xi’an 710077, ChinaFollow
ZHAO Chunhu, Xi’an Research Institute (Group) Co. Ltd., China Coal Technology and Engineering Group Corp., Xi’an 710077, China; Shaanxi Key Laboratory of Preventing and Controlling Technology for Coal Mine Water Hazard, Xi’an 710077, China; Shaanxi Province “Four Main Bodies and One Combination” School Enterprise Joint Research Center for Ecological Environment Protection and Restoration of Mining Areas (Coal Mines) in the Middle of Yellow River Basin, Xi’an 710077, ChinaFollow
LYU Hanjiang, Xi’an Research Institute (Group) Co. Ltd., China Coal Technology and Engineering Group Corp., Xi’an 710077, China; Shaanxi Key Laboratory of Preventing and Controlling Technology for Coal Mine Water Hazard, Xi’an 710077, China

Abstract

Regional advance grouting transformation and reinforcement of water conducting formation and aquifer is the main technical means to prevent and control the karst water hazards in the coal seam floor of North China type coalfields. Herein, analysis was conducted for the general application mode of the regional advance grouting transformation and reinforcement for water hazard treatment in the thin and thick limestone layers in the coal seam floor based on the basic mine hydrogeological principle of the application of regional advance grouting transformation technology. In the analysis, consideration was given to the hydrogeological structure of the coal seam floor, the influence of mining activities, the directional drilling hole, the grout diffusion capacity, and the boundary conditions of the grouting rock layer. Besides, analysis was also performed from the aspects of geological conditions of grouting rock stratum, grouting materials, grouting technology, etc. Thus, the main factors affecting the regional advance grouting treatment effect of karst water hazard in the coal seam floor were obtained, including the connectivity, openness, roughness and pore water bearing capacity of the grouting layer, the granularity, viscosity, time variation and firmness of grouting materials, and the grouting pressure, spatial layout of drilling holes, grouting methods, etc. In addition, according to the calculation formula of effective grouting pressure, the grout is inhibited by the comprehensive resistance of the borehole and the rock stratum gap during its flow in the borehole and fissure. As a result, the effective grouting pressure in the horizontal hole gradually decreases, which is easy to form a “cone” grout diffusion range. Finally, in view of the current commonly-used pattern of parallel arrangement of branch holes in horizontal section of regional advance grouting holes, the blind area between grouting holes may be caused by the excessive spacing and the attenuation of effective grouting pressure. Therefore, 3 types of efficient hole arrangement modes, such as the long-distance staggered parallel branch hole, the long-distance reverse complementary arc branch hole and short-distance feathery branch hole, were proposed according to the attenuation law of effective grouting pressure and grout diffusion range in the horizontal section of grouting holes, so as to eliminate the blind area of grouting. Hence, a basis could be provided for the scientific application of high efficient regional technology for water hazard treatment in the coal seam floor in advance.

Keywords

floor karst water hazard，reginal treatment，directional drilling，grouting material，grout diffusion，hole arrangement method

DOI

10.12363/issn.1001-1986.22.04.0279

Recommended Citation

HU Weiyue, ZHAO Chunhu, LYU Hanjiang, et al. (2022) "Main influencing factors for regional pre-grouting technology of water hazard treatment in coal seam floor and efficient hole arrangement," Coal Geology & Exploration: Vol. 50: Iss. 11, Article 15.
DOI: 10.12363/issn.1001-1986.22.04.0279
Available at: https://cge.researchcommons.org/journal/vol50/iss11/15

Reference

[1] 董书宁,郭小铭,刘其声,等. 华北型煤田底板灰岩含水层超前区域治理模式与选择准则[J]. 煤田地质与勘探,2020,48(4):1−10

DONG Shuning,GUO Xiaoming,LIU Qisheng,et al. Model and selection criterion of zonal preact grouting to prevent mine water disasters of coal floor limestone aquifer in North China type coalfield[J]. Coal Geology & Exploration,2020,48(4):1−10

[2] 《岩土注浆理论与工程实例》协作组. 岩土注浆理论与工程实例[M]. 北京：科学出版社，2001.

[3] 虎维岳,吕汉江. 饱水岩溶裂隙岩体注浆改造关键参数的确定方法[J]. 煤炭学报,2012,37(4):596−601

HU Weiyue,LYU Hanjiang. Determination method of key parameters of grouting in water saturated karst–fracture[J]. Journal of China Coal Society,2012,37(4):596−601

[4] 阮文军. 基于浆液粘度时变性的岩体裂隙注浆扩散模型[J]. 岩石力学与工程学报,2005,24(15):2709−2714

RUAN Wenjun. Spreading model of grouting in rock mass fissures based on time−dependent behavior of viscosity of cement–based grouts[J]. Chinese Journal of Rock Mechanics and Engineering,2005,24(15):2709−2714

[5] 柳昭星，董书宁，王皓. 承压倾斜裂隙水平孔注浆浆液扩散规律[J]. 煤炭学报，2022：1–20 [2022-10-21]. https://doi.org/10.13225/j.cnki.jccs.2022.0243.

LIU Zhaoxing，DONG Shuning，WANG Hao. Law of grout diffusion of horizontal hole grouting in confined inclined crack[J]. Journal of China Coal Society，2022：1–20 [2022-10-21]. https://doi.org/10.13225/j.cnki.jccs.2022.0243.

[6] 李术才,刘人太,张庆松,等. 基于黏度时变性的水泥–玻璃浆液扩散机制研究[J]. 岩石力学与工程学报,2013,32(12):2415−2421

LI Shucai,LIU Rentai,ZHANG Qingsong,et al. Research on C–S slurry diffusion mechanism with time–dependent behavior of viscosity[J]. Chinese Journal of Rock Mechanics and Engineering,2013,32(12):2415−2421

[7] 柳昭星,董书宁,王皓. 奥陶系灰岩顶部超前区域注浆浆液选配分析[J]. 地下空间与工程学报,2022,18(3):910−924

LIU Zhaoxing,DONG Shuning,WANG Hao. Analysis on grout selection and control of reformation grouting material in advance area of Ordovician limestone top[J]. Chinese Journal of Underground Space and Engineering,2022,18(3):910−924

[8] 徐健. 水泥–黏土–矿渣粉注浆材料性能试验研究[D]. 淮南：安徽理工大学，2019.

XU Jian. Experimental study on properties of cement–clay–slag grouting material[D]. Huainan：Anhui University of Science and Technology，2019.

[9] 张联志. 水泥–粉煤灰–黏土浆材配比优化及室内注浆试验研究[D]. 湘潭：湖南科技大学，2014.

ZHANG Lianzhi. Research on optimal ratio and indoor grouting test of cement−fly ash−clay grout[D]. Xiangtan：Hunan University of Science and Technology，2014.

[10] 赵庆彪. 奥灰岩溶水上带压开采区域超前治理防治水技术[J]. 煤炭科学技术,2014,42(8):1−4

ZHAO Qingbiao. Technology of regional advance water prevention and control applied to pressurized coal mining zone above Ordovician limestone karst water[J]. Coal Science and Technology,2014,42(8):1−4

[11] 郑士田. 两淮煤田煤层底板灰岩水害区域超前探查治理技术[J]. 煤田地质与勘探,2018,46(4):142−146

ZHENG Shitian. Advanced exploration and control technology of limestone water hazard in coal seam floor in Huainan and Huaibei coalfields[J]. Coal Geology & Exploration,2018,46(4):142−146

[12] 郑士田,马荷雯,姬亚东. 煤层底板水害区域超前治理技术优化及其应用[J]. 煤田地质与勘探,2021,49(5):167−173

ZHENG Shitian,MA Hewen,JI Yadong. Optimization of regional advanced coal floor water hazard prevention and control technology and its application[J]. Coal Geology & Exploration,2021,49(5):167−173

[13] ZIMMERMAN R W,BODVARSSON G S. Hydraulic conductivity of rock fractures[J]. Transport in Porous Media,1996,23:1−30.

[14] EKER E,AKIN S. Lattice boltzmann simulation of fluid flow in synthetic fractures[J]. Transport in Porous Media,2006,65(3):363−384.

[15] P. E. 格雷泰纳. 孔隙压力的基本原理通常所引起的后果及其构造地质含意[M]. 北京：石油工业出版社，1982.

[16] 甘磊,马洪影,沈振中. 下凹形态裂隙面粗糙程度表征及立方定律修正系数拟合[J]. 水利学报,2021,52(4):420−431

GAN Lei,MA Hongying,SHEN Zhenzhong. Roughness characterization of concave fracture surface and coefficient fitting of modified cubic law[J]. Journal of Hydraulic Engineering,2021,52(4):420−431

[17] 高明忠,金文城,郑长江,等. 采动裂隙网络实时演化及连通性特征[J]. 煤炭学报,2012,37(9):1535−1540

GAO Mingzhong,JIN Wencheng,ZHENG Changjiang,et al. Real–time evolution and connectivity of mined crack network[J]. Journal of China Coal Society,2012,37(9):1535−1540

[18] BARTON N,BANDIS S,BAKHTAR K. Strength,deformation and conductivity coupling of rock joints[J]. International Journal of Rock Mechanics and Mining Sciences & Geomechanics Abstracts,1985,22(3):121−140.

[19] ERIKSSON M,STILLE H,ANDERSSON J. Numerical calculations for prediction of grout spread with account for filtration and varying aperture[J]. Tunnelling and Underground Space Technology,2000,15(4):353−364.

[20] ERIKSSON M,FRIEDRICH M,VORSCHULZE C. Variations in the rheology and penetrability of cement–based grouts:An experimental study[J]. Cement and Concrete Research,2004,34(7):1111−1119.

[21] EKLUNDL D,STILLE H. Penetrability due to filtration tendency of cement–based grouts[J]. Tunnelling and Underground Space Technology,2008,23(4):389−398.

[22] 王凯. 深井微裂隙软岩高压注浆渗流特性及应用研究[D]. 徐州：中国矿业大学，2020.

WANG Kai. Study on the seepage characteristics and application of high pressure grouting in micro–fractured soft rock under deep mine[D]. Xuzhou：China University of Mining and Technology，2020.

[23] CHEGBELEH L P,NISHIGAKI M,AKUDAGO J A,et al. Experimental study on ethanol/bentonite slurry injection into synthetic rock fractures:Application to seepage control[J]. Applied Clay Science,2009,45(4):232−238.

[24] 柳昭星,尚宏波,石志远,等. 岩溶裂隙发育地层帷幕注浆材料性能及适用性研究[J]. 煤炭科学技术,2020,48(4):256−265

LIU Zhaoxing,SHANG Hongbo,SHI Zhiyuan,et al. Study on performance and applicability of curtain grouting materials in karst fractured stratum[J]. Coal Science and Technology,2020,48(4):256−265

[25] 白云,戴志仁,张莎莎,等. 盾构隧道同步注浆浆液压力扩散模式研究[J]. 中国铁道科学,2011,32(4):38−45

BAI Yun,DAI Zhiren,ZHANG Shasha,et al. Study on the grout pressure dissipation mode in simultaneous backfill grouting during shield tunneling[J]. China Railway Science,2011,32(4):38−45

[26] 周军霞,陆劲松,张玉,等. 考虑浆液粘时变性渗透注浆理论计算公式[J]. 材料科学与工程学报,2019,37(5):758−762

ZHOU Junxia,LU Jinsong,ZHANG Yu,et al. Calculation formula of permeation grouting considering slurry viscosity variation[J]. Journal of Materials Science and Engineering,2019,37(5):758−762

[27] 柳昭星,靳德武,尚宏波,等. 矿区岩溶裂隙岩体帷幕截流注浆参数确定研究[J]. 煤炭科学技术,2019,47(6):81−86

LIU Zhaoxing,JIN Dewu,SHANG Hongbo,et al. Study on determination of curtain closure grouting parameters of fractured rock mass in karst mining area[J]. Coal Science and Technology,2019,47(6):81−86

[28] 王宁,刘长来,吴杰. 水灰比对钻孔护孔泡沫混凝土抗压强度及渗透率影响研究[J]. 煤炭科技,2020,41(6):18−21

WANG Ning,LIU Changlai,WU Jie. Influence of water–grey ratio on pressure strength and permeability of borehole–support foam concrete[J]. Coal Science & Technology Magazine,2020,41(6):18−21

[29] 上官书民,赵伟,张胜军,等. 水泥–粉煤灰注浆材料特性试验研究[J]. 煤炭技术,2014,33(4):246−249

SHANGGUAN Shumin,ZHAO Wei,ZHANG Shengjun,et al. Characteristics of grouting materials on cement and fly ash[J]. Coal Technology,2014,33(4):246−249

[30] 吴爱祥,于少峰,韩斌,等. 超细水泥注浆溶液配比优化及扩散规律研究[J]. 采矿与安全工程学报,2014,31(2):304−309

WU Aixiang,YU Shaofeng,HAN Bin,et al. Optimization of mix–proportion and diffusing rule of super–fine cement grouting slurry[J]. Journal of Mining and Safety Engineering,2014,31(2):304−309

[31] 范梦甜,王迎斌,苏英,等. 超细粉煤灰对水泥性能的影响及在混凝土中的应用研究[J]. 新型建筑材料,2021,48(8):16−20

FAN Mengtian,WANG Yingbin,SU Ying,et al. Study on the effect of ultra–fine fly ash on cement performance and its application in concrete[J]. New Building Material,2021,48(8):16−20

[32] 郑士田. 地面顺层孔探注成套技术在底板高压岩溶水害治理中的应用[J]. 中国煤炭地质,2018,30(8):53−57

ZHENG Shitian. Application of complete set of surface bedding borehole exploration and grouting technology on floor high pressure karst water hazard governance[J]. Coal Geology of China,2018,30(8):53−57

[33] 赵庆彪,毕超,虎维岳,等. 裂隙含水层水平孔注浆“三时段”浆液扩散机理研究及应用[J]. 煤炭学报,2016,41(5):1212−1218

ZHAO Qingbiao,BI Chao,HU Weiyue,et al. Study and application of three–stage seriflux diffusion mechanism in the fissure of aquifer with horizontal injection hole[J]. Journal of China Coal Society,2016,41(5):1212−1218

[34] 李长青,方俊,李泉新,等. 煤层底板超前注浆加固定向孔注浆工艺技术[J]. 煤田地质与勘探,2014,42(4):59−63

LI Changqing,FANG Jun,LI Quanxin,et al. The grouting technology of directional borehole for pre–grouting reinforcement in coal floor[J]. Coal Geology & Exploration,2014,42(4):59−63

[35] 李振华,许延春,陈新明. 高水压工作面底板注浆加固技术研究[J]. 煤炭工程,2013,45(5):32−35

LI Zhenhua,XU Yanchun,CHEN Xinming. Study on grouting reinforcement technology of high water pressure floor in coal mining face[J]. Coal Engineering,2013,45(5):32−35