Inspection method and analysis of the effect of water cutoff curtain in open-pit coal mine

Authors

WANG Hai, Xi'an Research Institute Co. Ltd., China Coal Technology and Engineering Group Corp., Xi'an 710077, China; Shaanxi Key Laboratory of Coal Mine Water Hazard Prevention and Control Technology, Xi'an 710077, China
PENG Wei, Coal Branch of Huainan Mining Group, Huainan 232091, China
CAO Haidong, Xi'an Research Institute Co. Ltd., China Coal Technology and Engineering Group Corp., Xi'an 710077, China; Shaanxi Key Laboratory of Coal Mine Water Hazard Prevention and Control Technology, Xi'an 710077, China
WANG Li, Hulun Buir University, Hulun Buir 021122, China

Abstract

In order to reduce the water drainage of the studied open-pit mine, a curtain wall was constructed to cut off the river supply on the north side. According to the site construction conditions, four technologies were applied to construct the water cutoff curtain, such as the low-strength impermeable concrete underground continuous wall, HDPE impermeable film, ultra-high pressure angular variable speed jet grouting, and occluding pile. To test the effect of water cutoff curtain in the open-pit coal mine during construction, four surrounding well tests were carried out for three kinds of water cutoff curtain technologies, including low-strength impermeable concrete underground continuous wall, HDPE impermeable film and ultra-high pressure angular variable jet grouting. The test results show that the three technologies all had good water-blocking effects under the conditions of dynamic water and low temperature in the deep sand and gravel layer of the open-pit coal mine. The permeability coefficients respectively were 8.34×10^-7, 6.28×10^-7 and 7.85×10^-7 cm/s, which were basically consistent with the permeability coefficient obtained from the laboratory test of raw materials. Under the joint action of four curtain technologies, the water discharge was reduced obviously and the water intercepting effect was remarkable. The surrounding well test plays an inspecting role in the process of water cutoff curtain construction.

Keywords

open-pit coal mine, surrounding well test, water cutoff curtain, permeability coefficient, effect test

DOI

10.3969/j.issn.1001-1986.2020.04.013

Recommended Citation

WANG Hai, PENG Wei, CAO Haidong, et al. (2020) "Inspection method and analysis of the effect of water cutoff curtain in open-pit coal mine," Coal Geology & Exploration: Vol. 48: Iss. 4, Article 14.
DOI: 10.3969/j.issn.1001-1986.2020.04.013
Available at: https://cge.researchcommons.org/journal/vol48/iss4/14

Reference

[1] 李浩荡,佘长超,周永利,等. 我国露天煤矿开采技术综述及展望[J]. 煤炭科学技术,2019,47(10):24-35. LI Haodang,SHE Changchao,ZHOU Yongli,et al. Summary and prospect of open-pit coal mining technology in China[J]. Coal Science and Technology,2019,47(10):24-35.

[2] 张雁. 露天煤矿防渗墙截渗减排机制及工程应用研究[D]. 北京:煤炭科学研究总院,2018:1-3,112-119. ZHANG Yan. Study on the mechanism and engineering application of seepage cutoff and drainage reduction of diaphragm wall in open-pit coal mine[D]. Beijing:China Coal Research Institute,2018:1-3,112-119.

[3] 陈维池. 大型注浆帷幕隔水有效性数值分析与评价[D]. 徐州:中国矿业大学,2018. CHEN Weichi. Numerical analysis and evaluation of impermeability of large grouting curtain[D]. Xuzhou:China University of Mining & Technology,2018.

[4] 赵春虎,王强民,王皓,等. 东部草原区露天煤矿开采对地下水系统影响与帷幕保护分析[J]. 煤炭学报,2019,44(12):3685-3692. ZHAO Chunhu,WANG Qiangmin,WANG Hao,et al. Analysis of influence of open-pit coal mining on groundwater system and curtain wall protection in grassland area of northeastern China[J]. Journal of China Coal Society,2019,44(12):3685-3692.

[5] 柴建禄,姬中奎,杨帆,等. 大型烧变岩帷幕预注浆工程的即时检验技术[J]. 煤炭工程,2019,51(5):73-77. CHAI Jianlu,JI Zhongkui,YANG Fan,et al. Instant inspection technology of large-scale burnt rock curtain pre-grouting project[J]. Coal Engineering,2019,51(5):73-77.

[6] 张雁,黄选明,彭巍,等. 截水帷幕质量控制关键环节与效果检验方法[J]. 煤炭技术,2020,39(5):98-101. ZHANG Yan,HUANG Xuanming,PENG Wei,et al. Key links of quality control and methods of effect inspection of water cut-off curtain[J]. Coal Technology,2020,39(5):98-101.

[7] 杨勇. 复合式止水帷幕在临江深基坑中的应用研究[D]. 重庆:重庆大学,2015. YANG Yong. Study on the compound waterproof curtain in river-side deep foundation pit[D]. Chongqing:Chongqing University,2015.

[8] 靳德武,刘其声,王琳,等. 煤矿(床)水文地质学的研究现状及展望[J]. 煤田地质与勘探,2009,37(5):28-31. JIN Dewu,LIU Qisheng,WANG Lin,et al. Development and prospect of coal deposit hydrogeology[J]. Coal Geology & Exploration,2009,37(5):28-31.

[9] 王皓. 含水煤层水害形成机理及防治技术[J]. 煤田地质与勘探,2019,47(3):117-123. WANG Hao. Formation mechanism of coal seam aquifer and water hazard control technology[J]. Coal Geology & Exploration,2019,47(3):117-123.

[10] 王海,黄选明,朱明诚,等. 基于高掺量粉煤灰防渗墙的露天矿水资源保护技术[J]. 煤炭学报,2020,45(3):1160-1169. WANG Hai,HUANG Xuanming,ZHU Mingcheng,et al. Water-preserved coal mining technology in open pit based on cutoff wall with high fly ash content[J]. Journal of China Coal Society,2020,45(3):1160-1169.

[11] 丁冠涛,刘玉仙,孙中瑾,等. 北方某废弃矿区地下水污染帷幕注浆应急处置研究[J]. 地质学报,2019,93(增刊1):291-300. DING Guantao,LIU Yuxian,SUN Zhongjin,et al. Emergency disposal of groundwater contamination curtain grouting in an abandoned mining area in North China[J]. Acta Geologica Sinica,2019,93(Sup.1):291-300.

[12] 董书宁,杨志斌,姬中奎,等. 神府矿区大型水库旁烧变岩水保水开采技术研究[J]. 煤炭学报,2019,44(3):709-717. DONG Shuning,YANG Zhibin,JI Zhongkui,et al. Study on water-preserved mining technology of burnt rock aquifer beside the large reservoir in Shenfu mining area[J]. Journal of China Coal Society,2019,44(3):709-717.

[13] 姬中奎,薛小渊,杨志斌,等. 神府煤田张家峁煤矿烧变岩与水库水力联系研究[J]. 中国煤炭地质,2019,31(4):57-61. JI Zhongkui,XUE Xiaoyuan,YANG Zhibin,et al. Study on hydraulic connection between burnt rock and reservoir in Zhangjiamao coal mine,Shenfu coalfield[J]. Coal Geology of China,2019,31(4):57-61.

[14] 中华人民共和国国家发展和改革委员会. 水电水利工程高压喷射灌浆技术规范:DL/T 5200-2019[S]. 北京:中国电力出版社,2005. National Development and Reform Commission. Technical specification of jet grouting for hydropower and water resources projects:DL/T 5200-2019[S]. Beijing:China Electric Power Press,2005.

[15] 杨栋,徐拴海,姚安涛. 35 m厚流砂层旋喷围井试验[J]. 煤矿机械,2016,37(12):39-41. YANG Dong,XU Shuanhai,YAO Antao. High pressure jet grouting piles surrounding well test of 35 m flow sand seam[J]. Coal Mine Machinery,2016,37(12):39-41.

[16] 李晓凤,彭洪阁. 草原地区露天煤矿浅层地下水帷幕技术应用研究[J]. 中国煤炭,2013,39(7):47-50. LI Xiaofeng,PENG Hongge. Application research of shallow groundwater curtain technology in open-pit coal mine in prairie region[J]. China Coal,2013,39(7):47-50.

[17] 明福林,周玉学,杨晓龙,等. 复合防渗墙围井注水渗透试验[J]. 铁道建筑,2012(9):71-74. MING Fulin,ZHOU Yuxue,YANG Xiaolong,et al. Water injection test of compound impervious wall surrounding well[J]. Railway Engineering,2012(9):71-74.

[18] 张家柱. 黏土与细砂互层渗流控制的围井抽水试验研究[J]. 中国农村水利水电,2014(4):123-125. ZHANG Jiazhu. Research on well pumping tests based on the seepage control of clay and fine sand inter-beds[J]. China Rural Water and Hydropower,2014(4):123-125.

[19] 中华人民共和国住房和城乡建设部. 水电水利工程工程地质勘察规范:GB 50487-2008[S]. 北京:中国计划出版社,2009. Ministry of Housing and Urban-Rural Development of the People's Republic of China. Code for engineering geological investigation of water resources and hydropower:GB 50487-2008[S]. Beijing:China Planning Press,2009.

[20] 张雁,田增林,曹海东,等. MJS工法在砾石层中的应用及成桩差异性[J]. 煤田地质与勘探,2020,48(2):147-152. ZHANG Yan,TIAN Zenglin,CAO Haidong,et al. Application of MJS construction method in gravel layer and difference of pile forming[J]. Coal Geology & Exploration,2020,48(2):147-152.