Dynamic disaster evolution mechanism of high mine pressure at hard roof and advance area prevention and control technology

Authors

ZHENG Kaige, Xi’an Research Institute Co. Ltd., China Coal Technology Engineering Group Corp., Xi’an 710077, China; School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, ChinaFollow
WANG Lintao, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China
LI Bingang, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China
LI Yanjun, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China
YANG Huan, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China
YANG Sen, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China
DAI Nan, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China
WANG Haojie, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China
WANG Zeyang, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China
XI Jie, School of Earth and Environment, Anhui University of Science and Technology, Huainan 232001, China

Abstract

The overlying roof on the hard roof working bench is usually not likely to fall off, while tends to form dynamic pressure disaster. The stress evolution characteristics and roof breaking mechanism before and after hard roof weakening were analyzed and revealed using the methods of numerical simulation and theoretical analysis, and the advance area prevention and control technology were proposed and applied in the field practice, for the typical dynamic disaster problem of high mine pressure that was caused by the hard roof against the background of the Buertai Coal Mine in the Shendong Mine Area. As indicated by the results, there were three stages of the hard roof breaking evolution characteristics, i.e. the “long cantilever” stage — “masonry beam falling and destabilization” stage — re-compaction stage. At the “long cantilever” stage, which was also the main stage of weakening modification and control, the roof stress at the upper support was increased significantly to 6.8 MPa; the roof stress at the upper support before breaking was twice of that after breaking; the stress relief resulted from the critical breaking was the root cause of the high mine pressure. On the basis of the occurrence mechanism analysis of the hard roof disaster, the advance area prevention and control technology of "wide-range large space" was proposed, and the green, accurate and wide-range prevention and control advantages, the key technologies of drilling trajectory control, hole plugging quality control and multi-hole linkage effects as well as the governing evaluation system were elaborated. The reliability of the prevention and control technologies were verified in combination of the numerical simulation. After the "long cantilever" structure weakening, the roof stress at the upper support before breaking was 4.6 MPa, with the drop rate of 32.4%. The three stages of the roof breaking evolution characteristics were pre-weighting stage — “masonry beam falling and destabilization” stage — re-compaction stage. After weakening, the drop rate of the roof stress at the upper support for each stage was 32.4%–79.4%, which indicated that the preformed fissure weak surface and the hard stratum integrity reduction can effectively change the roof breaking structure and significantly decrease the weighting intensity. As indicated by the practice, the pressure drop occurred several times during fracturing, the drop rate was over 3 MPa, and the detection fracture developed to more than 30 m; the drop rate of the periodic weighting interval of the working bench before and after fracturing was 44.9%, and the drop rate of the support weighting load was 18.1%. The governing effect was good. The study result can provide references for the dynamic disaster governing in the similar mine areas.

Keywords

high mine pressure disaster, area prevention and control technology, hard roof, wide-range large space, directional long borehole, Boertai coal mine in Shendong Mining Area

DOI

10.12363/issn.1001-1986.22.04.0222

Recommended Citation

ZHENG Kaige, WANG Lintao, LI Bingang, et al. (2022) "Dynamic disaster evolution mechanism of high mine pressure at hard roof and advance area prevention and control technology," Coal Geology & Exploration: Vol. 50: Iss. 8, Article 8.
DOI: 10.12363/issn.1001-1986.22.04.0222
Available at: https://cge.researchcommons.org/journal/vol50/iss8/8

Reference

[1] 康红普,张镇,黄志增. 我国煤矿顶板灾害的特点及防控技术[J]. 煤矿安全,2020,51(10):24−33. KANG Hongpu,ZHANG Zhen,HUANG Zhizeng. Characteristics of roof disasters and controlling techniques of coal mine in China[J]. Safety in Coal Mines,2020,51(10):24−33.

[2] 于斌. 大同矿区侏罗系煤层群开采冲击地压防治技术[J]. 煤炭科学技术,2013,41(9):62−65. YU Bin. Prevention and control technology of pressure bump in Jurassic system seams group in Datong mining area[J]. Coal Science and Technology,2013,41(9):62−65.

[3] 杜涛涛,李国营,陈建强,等. 新疆地区冲击地压发生及防治现状[J]. 煤矿开采,2018,23(2):5−10. DU Taotao,LI Guoying,CHEN Jianqiang,et al. Rock burst occurrence and prevention status in Xinjiang Region[J]. Coal Mining Technology,2018,23(2):5−10.

[4] 朱德仁,钱鸣高,徐林生. 坚硬顶板来压控制的探讨[J]. 煤炭学报,1991,16(2):11−20. ZHU Deren,QIAN Minggao,XU Linsheng. Discussion on control of hard roof weighting[J]. Journal of China Coal Society,1991,16(2):11−20.

[5] 李新华,张向东. 浅埋煤层坚硬直接顶破断诱发冲击地压机理及防治[J]. 煤炭学报,2017,42(2):510−517. LI Xinhua,ZHANG Xiangdong. Mechanism and prevention of rock–burst induced by immediate roof breakage in shallow–buried coal seam[J]. Journal of China Coal Society,2017,42(2):510−517.

[6] 徐刚,于健浩,范志忠,等. 国内典型顶板条件工作面矿压显现规律[J]. 煤炭学报,2021,46(增刊1):25−37. XU Gang,YU Jianhao,FAN Zhizhong,et al. Characteristics of strata pressure behavior of working face under typical roof conditions in China[J]. Journal of China Coal Society,2021,46(Sup.1):25−37.

[7] 于斌,刘长友,杨敬轩,等. 坚硬厚层顶板的破断失稳及其控制研究[J]. 中国矿业大学学报,2013,42(3):342−348. YU Bin,LIU Changyou,YANG Jingxuan,et al. Research on the fracture instability and its control technique of hard and thick roof[J]. Journal of China University of Mining & Technology,2013,42(3):342−348.

[8] 王开,康天合,李海涛,等. 坚硬顶板控制放顶方式及合理悬顶长度的研究[J]. 岩石力学与工程学报,2009,28(11):2320−2327. WANG Kai,KANG Tianhe,LI Haitao,et al. Study of control caving methods and reasonable hanging roof length on hard roof[J]. Chinese Journal of Rock Mechanics and Engineering,2009,28(11):2320−2327.

[9] 刘长友,杨敬轩,于斌,等. 覆岩多层坚硬顶板条件下特厚煤层综放工作面支架阻力确定[J]. 采矿与安全工程学报,2015,32(1):7−13. LIU Changyou,YANG Jingxuan,YU Bin,et al. Support resistance determination of fully mechanized top−coal caving face in extra thick seam under multi−layered hard strata[J]. Journal of Mining & Safety Engineering,2015,32(1):7−13.

[10] 杨敬轩,刘长友,于斌,等. 坚硬厚层顶板群结构破断的采场冲击效应[J]. 中国矿业大学学报,2014,43(1):8−15. YANG Jingxuan,LIU Changyou,YU Bin,et al. Impact effect caused by the fracture of thick and hard roof structures in a longwall face[J]. Journal of China University of Mining & Technology,2014,43(1):8−15.

[11] 夏彬伟,李晓龙,卢义玉,等. 大同矿区坚硬顶板破断步距及变形规律研究[J]. 采矿与安全工程学报,2016,33(6):1038−1044. XIA Binwei,LI Xiaolong,LU Yiyu,et al. Study on the breaking span and deformation of hard roof in Datong mining area[J]. Journal of Mining & Safety Engineering,2016,33(6):1038−1044.

[12] 宋高峰,王振伟,钟晓勇. 坚硬顶板破断冲击机理及支架与围岩“收敛–约束”耦合机制研究[J]. 采矿与安全工程学报,2020,37(5):951−959. SONG Gaofeng,WANG Zhenwei,ZHONG Xiaoyong. Dynamic impact mechanism of hard roof strata and coupling mechanism of “constrain–convergence”between support and surrounding rock[J]. Journal of Mining & Safety Engineering,2020,37(5):951−959.

[13] 冯彦军,康红普. 定向水力压裂控制煤矿坚硬难垮顶板试验[J]. 岩石力学与工程学报,2012,31(6):1148−1155. FENG Yanjun,KANG Hongpu. Test on hard and stable roof control by means of directional hydraulic fracturing in coal mine[J]. Chinese Journal of Rock Mechanics and Engineering,2012,31(6):1148−1155.

[14] 何江,窦林名,巩思园,等. 倾斜薄煤层切顶巷预裂顶板防治冲击矿压技术研究[J]. 煤炭学报,2015,40(6):1347−1352. HE Jiang,DOU Linming,GONG Siyuan,et al. Research on rock burst prevention technology of roof–cutting roadway in inclined thin coal seam[J]. Journal of China Coal Society,2015,40(6):1347−1352.

[15] 张自政,柏建彪,陈勇,等. 浅孔爆破机制及其在厚层坚硬顶板沿空留巷中的应用[J]. 岩石力学与工程学报,2016,35(增刊1):3008−3017. ZHANG Zizheng,BAI Jianbiao,CHEN Yong,et al. Shallow−hole blasting mechanism and its application for gob−side entry retaining with thick and hard roof[J]. Chinese Journal of Rock Mechanics and Engineering,2016,35(Sup.1):3008−3017.

[16] 黄炳香,赵兴龙,陈树亮,等. 坚硬顶板水压致裂控制理论与成套技术[J]. 岩石力学与工程学报,2017,36(12):2954−2970. HUANG Bingxiang,ZHAO Xinglong,CHEN Shuliang,et al. Theory and technology of controlling hard roof with hydraulic fracturing in underground mining[J]. Chinese Journal of Rock Mechanics and Engineering,2017,36(12):2954−2970.

[17] 郑凯歌,杨俊哲,李彬刚,等. 基于垮落充填的坚硬顶板分段压裂弱化解危技术[J]. 煤田地质与勘探,2021,49(5):77−87. ZHENG Kaige,YANG Junzhe,LI Bingang,et al. Collapse filling–based technology of weakening and danger–solving by staged fracturing in hard roof[J]. Coal Geology & Exploration,2021,49(5):77−87.

[18] 郑凯歌. 碎软低透煤层底板梳状长钻孔分段水力压裂增透技术研究[J]. 采矿与安全工程学报,2020,37(2):272−281. ZHENG Kaige. Permeability improving technology by sectional hydraulic fracturing for comb–like long drilling in floor of crushed and soft coal seam with low permeability[J]. Journal of Mining & Safety Engineering,2020,37(2):272−281.

[19] 杨俊哲,郑凯歌,赵继展,等. 浅埋近距离上覆遗留煤柱应力集中灾害压裂治理技术研究[J]. 矿业安全与环保,2020,47(4):82−87. YANG Junzhe,ZHENG Kaige,ZHAO Jizhan,et al. Research on fracturing treatment technology of concentrated stress disaster by the overlying coal pillar in close distance shallow seam[J]. Mining Safety & Environmental Protection,2020,47(4):82−87.

[20] 杨俊哲,郑凯歌,王振荣,等. 坚硬顶板动力灾害超前弱化治理技术[J]. 煤炭学报,2020,45(10):3371−3379. YANG Junzhe,ZHENG Kaige,WANG Zhenrong,et al. Technology of weakening and danger–breaking dynamic disasters by hard roof[J]. Journal of China Coal Society,2020,45(10):3371−3379.

[21] 于斌,高瑞,夏彬伟,等. 大空间坚硬顶板地面压裂技术与应用[J]. 煤炭学报,2021,46(3):800−811. YU Bin,GAO Rui,XIA Binwei,et al. Ground fracturing technology and application of hard roof in large space[J]. Journal of China Coal Society,2021,46(3):800−811.

[22] 鞠金峰,许家林,王庆雄. 大采高采场关键层“悬臂梁”结构运动型式及对矿压的影响[J]. 煤炭学报,2011,36(12):2115−2120. JU Jinfeng,XU Jialin,WANG Qingxiong. Cantilever structure moving type of key strata and its influence on ground pressure in large mining height workface[J]. Journal of China Coal Society,2011,36(12):2115−2120.

[23] 钱鸣高,缪协兴,何富连. 采场“砌体梁”结构的关键块分析[J]. 煤炭学报,1994,19(6):557−563. QIAN Minggao,MIAO Xiexing,HE Fulian. Analysis of key block in the structure of voussoir beam in longwall mining[J]. Journal of China Coal Society,1994,19(6):557−563.